2009 Ford F-650 SD Problems, Complaints & Recalls
- Compared with other F-650 SD years
- Not enough data 10th of 18 for complaints
- Safety recalls
- 3 recalls: check your VIN
- NHTSA crash rating
- Not rated
Owners have filed 1 complaint with NHTSA about the 2009 Ford F-650 SD. That ranks 10th out of 18 F-650 SD model years for complaints. The most reported problem area is service brakes (1 complaints, 100%), typically at around 17,000 miles. There are 3 safety recalls covering this model year.
- 1owner complaints
- 3safety recalls
- 0NHTSA investigations
- 0complaints mentioning a crash
Complaints are unverified owner reports and are not adjusted for sales volume.
Most common 2009 Ford F-650 SD problems
Complaints grouped by the part of the car owners reported, with the median mileage when the problem happened.
| Problem area | Complaints | Share | Median miles | Owners mention most | Typical repair cost |
|---|---|---|---|---|---|
| Service Brakes | 1 | 100% | 17,000 | — | — |
One complaint can list several problem areas, so shares can add up to more than 100%.
2009 Ford F-650 SD recalls (3)
Tap a recall to see the problem, the risk and the fix.
Engine and engine cooling
Problem: Ford is recalling certain model year 2008-2009 f-650 and f-750 trucks equipped with caterpillar c7 engine. The #5 and #6 fuel lines may crack at the fastening point to the common fuel rail and cause a fuel leak.
Risk: A fuel leak, in the presence of an ignition source, can result in a vehicle fire.
Fix: Ford is working with caterpillar to notify owners and repairs will be performed by authorized caterpillar dealers free of charge. The safety recall began on september 8, 2010. Owners may contact caterpillar toll-free at 1-800-447-4986 or ford at 1-866-436-7332.
Exterior lighting
Problem: Ford is recalling model years 2009 f-650 and f-750 trucks. The chassis wire harness may have been assembled without a connector seal if this seal is missing, the connector terminals may corrode affecting the proper illumination of the vehicle's rear brake lamps, tail lamps, turn signal lamps or trailer lamps (if equipped.) also, the function of the anti-lock brake system may be affected.
Risk: Inoperative lamps may increase the risk of a crash.
Fix: Dealers will inspect the connector and repair the main and rear chassis wire harness if necessary. A missing seal will be replaced and electrical grease applied to prevent future corrosion. The safety recall began on december 16, 2009. Owners may contact ford at 1-866-436-7332 or through the internet at www.fordowner.com.
Engine and engine cooling:engine:diesel
Problem: Ford is recalling 2,811 my 2008-2009 f-650 and f-750 trucks equipped with c7 or c9 caterpillar diesel engines. The fuel pump outlet check plug may be cracked which could cause fuel to spray and leak.
Risk: Fuel leakage, in the presence of an ignition source, could result in a fire.
Fix: Ford is working with caterpillar (please see 08e042). Caterpillar will replace the fuel pump plug free of charge. Owners may contact caterpillar at 1-800-447-4986, or ford at 1-800-343-5338 (fleet owners) or 1-866-906-9811 (motor home owners).
To see whether a specific car still has an open recall, enter its VIN on NHTSA's official recall lookup. You can also decode a VIN here.
Recent owner reports
Short excerpts of the latest complaints filed with NHTSA, with personal details removed. Full reports can be searched on NHTSA.gov.
Tl* the contact owns a 2009 ford f-650 sd. The contact stated that while driving at approximately 40 mph, the brake pedal was depressed but the brakes failed to respond. The contact had to make a sharp left turn to avoid crashing into a vehicle. The emergency brake was activated and shifted the…
Other Ford F-650 SD years
← 2008 F-650 SD · 2010 F-650 SD →
| Year | Complaints | Recalls |
|---|---|---|
| 2026 F-650 SD | 1 | 0 |
| 2025 F-650 SD | 4 | 3 |
| 2023 F-650 SD | 2 | 1 |
| 2021 F-650 SD | 1 | 1 |
| 2019 F-650 SD | 4 | 0 |
| 2018 F-650 SD | 0 | 5 |
| 2016 F-650 SD | 3 | 3 |
| 2015 F-650 SD | 1 | 4 |
| 2013 F-650 SD | 0 | 1 |
| 2012 F-650 SD | 0 | 1 |
| 2011 F-650 SD | 1 | 3 |
| 2010 F-650 SD | 0 | 1 |
| 2009 | 1 | 3 |
| 2008 F-650 SD | 2 | 4 |
| 2007 F-650 SD | 5 | 1 |
| 2006 F-650 SD | 3 | 0 |
| 2005 F-650 SD | 6 | 2 |
| 2004 F-650 SD | 10 | 2 |
See all Ford F-650 SD problems by year, every Ford model, or the Ford VIN decoder.
Similar Ford models
Embed this 2009 Ford F-650 SD badge on your site
Copy this code into your blog or forum post. It shows live complaint and recall counts and links back here.
Frequently asked questions
What are the most common problems with the 2009 Ford F-650 SD?
Owners most often report service brakes problems. The top one, service brakes, accounts for 1 complaint.
Was there a recall on the 2009 Ford F-650 SD?
Yes, 3 safety recalls. Enter your VIN at NHTSA.gov to check whether the repairs were done on your car.
Was the 2009 Ford F-650 SD a good year?
Complaint data can't fully answer that, because counts aren't adjusted for sales. Compared with other F-650 SD model years, the 2009 has too little data to compare. Always get a pre-purchase inspection and check the VIN for open recalls.