2004 Ic HC Problems, Complaints & Recalls
- Compared with other HC years
- Not enough data 1st of 5 for complaints
- Safety recalls
- 2 recalls: check your VIN
- NHTSA crash rating
- Not rated
NHTSA has received no owner complaints about the 2004 Ic HC so far. There are 2 safety recalls covering this model year. NHTSA has opened 1 defect investigation involving it.
- 0owner complaints
- 2safety recalls
- 1NHTSA investigations
- 0complaints mentioning a crash
Complaints are unverified owner reports and are not adjusted for sales volume.
2004 Ic HC recalls (2)
Tap a recall to see the problem, the risk and the fix.
Engine and engine cooling
Problem: Navistar is recalling 24,975 my 2003 through 2008 ic be, ce, hc, and re school and commercial buses and 2002 through 2008 international 3200 and 3300 model buses manufactured between september 21, 2001 through december 14, 2007, equipped with international vt365 engines. These vehicles may exhibit engine hard start, no start, or stall conditions due to possibly damaged terminals in the fuse holder connector of the injector drive module (idm) clean battery power circuits. The terminals may have been damaged during electrical continuity testing in the manufacturing process.
Risk: These conditions could result in a vehicle crash, possibly resulting in personal injury.
Fix: Navistar will notify owners and replace the idm fuse holder free of charge. The recall began on october 3, 2008. Owners can contact navistar toll-free at 1-800-448-7825.
Electrical system
Problem: Navistar is recalling 51,588 heavy trucks, commercial buses and school buses manufactured between november 21, 2000 and may 21, 2008, equipped with one or more remote power modules. The potting material that encapsulates the circuit board of the vehicle's remote power module may not sufficiently seal the circuit board from water and contamination intrusion. If the encapsulation is compromised, water and contaminants may cause an internal electrical short, possibly resulting in a fire.
Risk: A fire could cause personal injury or death.
Fix: Navistar will notify owners and repair the vehicles free of charge. The recall began on july 10, 2008. Owners may contact navistar at 1-280-461-1890.
To see whether a specific car still has an open recall, enter its VIN on NHTSA's official recall lookup. You can also decode a VIN here.
NHTSA defect investigations
- School bus stalling (PE08034) — opened May 9, 2008, closed Aug 28, 2008, led to recall 08V353000.
Other Ic HC years
See all Ic HC problems by year, every Ic model, or the VIN decoder.
Embed this 2004 Ic HC badge on your site
Copy this code into your blog or forum post. It shows live complaint and recall counts and links back here.
Frequently asked questions
What are the most common problems with the 2004 Ic HC?
NHTSA has no owner complaints on file yet.
Was there a recall on the 2004 Ic HC?
Yes, 2 safety recalls. Enter your VIN at NHTSA.gov to check whether the repairs were done on your car.
Was the 2004 Ic HC a good year?
Complaint data can't fully answer that, because counts aren't adjusted for sales. Compared with other HC model years, the 2004 has too little data to compare. Always get a pre-purchase inspection and check the VIN for open recalls.