2002 Monaco Coach Monarch SE Problems, Complaints & Recalls

Problem: On certain class a motor h0mes built with gasoline engines, the frame extension lower flange may crack allowing the hitch to bend and possibly separate from the motor home.

Risk: This could result in separation of the towed vehicle.

Fix: Dealers will add an addition of two pieces of angle steel to the frame extension and hitch mounting point in order to reinforce the frame extension flange free of charge. The recall began on february 15, 2007. Owners may contact monaco at 877-466-6226. Note: the ending manufacturing date for indiana built motor homes is march 8, 2002 while the oregon built motor homes were built through november 2002. The federal id label located on the wall next to the driver's seat specifies in which state the motor home was built.

Problem: Certain motor home chassis fail to comply with the requirements of federal motor vehicle safety standard no. 105, "hydraulic and electric brake systems." the brake system warning indicator may not function as required by standard.

Risk: In some of the affected vehicles, the brake system warning indicator will not illuminate when the ignition is in the start position or for a low brake fluid condition, if the body builder relied solely upon ford's ivm compliance statement for the brake system warning indicator.

Fix: Dealers will repair the brake warning lamp circuit. Owner notification began may 7, 2003. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact monaco coach at 1-877-477-6226.

Problem: On certain motor homes, the brake assemblies exhibit elevated temperatures that can lead to catastrophic deterioration of the wheel end components such as bearings, races, spindles, knuckles, seals, hubs, rotors, patch bolts, calipers, brake pads, and abs sensors.

Risk: This could result in loss of control, and/or the potential for a fire.

Fix: Dealers will inspect the front and rear brake calipers for corrosion and replace or rebuild the calipers as necessary. The recall began on august 18, 2004. Owners should contact monaco at 1-800-685-6545.

Problem: On certain class a motor homes, the floor truss network support system has a potential to weaken causing internal and external features to become misaligned. The affected vehicles are 1999 - 2003 class a motor homes manufactured on f53 20,500 pound gross vehicle weight rating (gvwr), ford chassis, and 2000-2003 class a motor homes manufactured on w-22 22,000 pound gvwr, workhorse chassis.

Risk: Conditions can result in the bottoming out the suspension and amplification of the stress placed on the floor truss network. The additional stress can result in the fracture of welds securing the floor truss network system to the chassis frame rail and/or fracture of the floor truss network support system. The possibility exists that there could be damage to electrical wiring and/or fuel lines which could potentially lead to a fire.

Fix: Dealers will inspect the floor truss network support system, reinforce the existing structure, and repair, as needed, the floor truss network support. Owner notification began november 5, 2002. Owners should contact monaco at 1-800-685-6545.