2016 Terex General 80 Problems, Complaints & Recalls
- Compared with other General 80 years
- Not enough data 1st of 19 for complaints
- Safety recalls
- 2 recalls: check your VIN
- NHTSA crash rating
- Not rated
NHTSA has received no owner complaints about the 2016 Terex General 80 so far. There are 2 safety recalls covering this model year.
- 0owner complaints
- 2safety recalls
- 0NHTSA investigations
- 0complaints mentioning a crash
Complaints are unverified owner reports and are not adjusted for sales volume.
2016 Terex General 80 recalls (2)
Tap a recall to see the problem, the risk and the fix.
Equipment
Problem: Terex south Dakota, Inc. (Terex) is recalling certain 2015-2018 Terex C4000, C5000, C6000, and General digger derricks. The welds between the coupler and hex shaft may be undersized, causing them to fail and the auger to fall unexpectedly.
Risk: If the auger falls, it can increase the risk of injury to the user or bystanders.
Fix: Terex will notify owners, and dealers will either repair the weld or replace the affected component, free of charge. The recall began October 3, 2018. Owners may contact Terex customer service at 1-605-882-4000. Terex's number for this recall is SN665.
Suspension:front:springs:air suspension:springs/bags
Problem: Terex South Dakota, Inc. (Terex) is recalling certain model year 2015-2016 C5000, C6000, General 80, RMX, TM100, and TM125 aerial devices, and digger derrick lifts installed on trucks manufactured August 4, 2015, to February 16, 2016. The suspension circuit can inflate the suspension air bags on the affected vehicles if the Master/PTO switch or ignition is turned off in the cab while the boom is in the raised position. This can cause the frame to rise, lifting the outriggers from the ground.
Risk: If the outrigger lifts off the ground, causing instability of the truck, it can increase the risk of injury to the operator.
Fix: Terex will notify owners, and dealers will install a second outrigger enable relay, free of charge. The recall began on April 29, 2016. Owners may contact Terex customer service at 1-800-982-8975. Terex's number for this recall is SN636.
To see whether a specific car still has an open recall, enter its VIN on NHTSA's official recall lookup. You can also decode a VIN here.
Other Terex General 80 years
← 2015 General 80 · 2017 General 80 →
See all Terex General 80 problems by year, every Terex model, or the VIN decoder.
Embed this 2016 Terex General 80 badge on your site
Copy this code into your blog or forum post. It shows live complaint and recall counts and links back here.
Frequently asked questions
What are the most common problems with the 2016 Terex General 80?
NHTSA has no owner complaints on file yet.
Was there a recall on the 2016 Terex General 80?
Yes, 2 safety recalls. Enter your VIN at NHTSA.gov to check whether the repairs were done on your car.
Was the 2016 Terex General 80 a good year?
Complaint data can't fully answer that, because counts aren't adjusted for sales. Compared with other General 80 model years, the 2016 has too little data to compare. Always get a pre-purchase inspection and check the VIN for open recalls.