2019 Terex TL80 Problems, Complaints & Recalls
- Compared with other TL80 years
- Not enough data 1st of 2 for complaints
- Safety recalls
- 2 recalls: check your VIN
- NHTSA crash rating
- Not rated
NHTSA has received no owner complaints about the 2019 Terex TL80 so far. There are 2 safety recalls covering this model year.
- 0owner complaints
- 2safety recalls
- 0NHTSA investigations
- 0complaints mentioning a crash
Complaints are unverified owner reports and are not adjusted for sales volume.
2019 Terex TL80 recalls (2)
Tap a recall to see the problem, the risk and the fix.
Equipment
Problem: Terex South Dakota, Inc. (Terex) is recalling certain 2019-2020 TL80 and TL100 aerial devices. The rotation bearing bolts may loosen during unit use, causing them to fail.
Risk: If the rotation bearing bolts fail, the boom could fall, increasing the risk of injury or death.
Fix: Terex will notify owners, and dealers will install Field Service Kit Z1604 which includes replacement rotation bearing bolts, washers, pedestal reinforcement plates, and bolt spacers, free of charge. Owners are advised to perform a pre-shift inspection procedure until the repair is complete. The recall began November 24, 2020. Owners may contact Terex customer service at 1-605-882-4000. Terex's number for this recall is SN687.
Equipment
Problem: Terex South Dakota, Inc. (Terex) is recalling certain 2019-2020 TL80 and TL80/112 aerial devices. The installed slope indicator and decals incorrectly state that the chassis can be 5 degrees out of level for aerial device use.
Risk: If the aerial device is used with the chassis out of level it may result in an unstable condition which may cause the unit to tip, increasing the risk of injury to the operator and any bystanders.
Fix: Terex will notify owners, and dealers will replace the incorrect slope indicator and decals, free of charge. The recall began May 12, 2020. Owners may contact Terex customer service at 1-605-882-4000. Terex's number for this recall is SN685.
To see whether a specific car still has an open recall, enter its VIN on NHTSA's official recall lookup. You can also decode a VIN here.
Other Terex TL80 years
| Year | Complaints | Recalls |
|---|---|---|
| 2020 TL80 | 0 | 2 |
| 2019 | 0 | 2 |
See all Terex TL80 problems by year, every Terex model, or the VIN decoder.
Embed this 2019 Terex TL80 badge on your site
Copy this code into your blog or forum post. It shows live complaint and recall counts and links back here.
Frequently asked questions
What are the most common problems with the 2019 Terex TL80?
NHTSA has no owner complaints on file yet.
Was there a recall on the 2019 Terex TL80?
Yes, 2 safety recalls. Enter your VIN at NHTSA.gov to check whether the repairs were done on your car.
Was the 2019 Terex TL80 a good year?
Complaint data can't fully answer that, because counts aren't adjusted for sales. Compared with other TL80 model years, the 2019 has too little data to compare. Always get a pre-purchase inspection and check the VIN for open recalls.