2021 Thor Motor Coach Chateau Problems, Complaints & Recalls
- Compared with other Chateau years
- Not enough data 2nd of 24 for complaints
- Safety recalls
- 2 recalls: check your VIN
- NHTSA crash rating
- Not rated
Owners have filed 2 complaints with NHTSA about the 2021 Thor Motor Coach Chateau. That ranks 2nd out of 24 Chateau model years for complaints. The most reported problem area is engine (1 complaints, 50%). There are 2 safety recalls covering this model year.
- 2owner complaints
- 2safety recalls
- 0NHTSA investigations
- 0complaints mentioning a crash
Complaints are unverified owner reports and are not adjusted for sales volume.
Most common 2021 Thor Motor Coach Chateau problems
Complaints grouped by the part of the car owners reported, with the median mileage when the problem happened.
| Problem area | Complaints | Share | Median miles | Owners mention most | Typical repair cost |
|---|---|---|---|---|---|
| Engine | 1 | 50% | — | — | — |
| Unknown or Other | 1 | 50% | — | — | — |
One complaint can list several problem areas, so shares can add up to more than 100%.
Complaints by year received
2021 Thor Motor Coach Chateau recalls (2)
Tap a recall to see the problem, the risk and the fix.
Electrical system:12v/24v/48v battery:cables
Problem: Thor Motor Coach (TMC) is recalling certain 2021 Daybreak, Four Winds, Quantum, Chateau, and Freedom Elite motorhomes built on the 2020 Ford E-Series chassis. The battery cable may not have been properly secured within the chassis rail, which can cause it to contact the exhaust manifold and heat shield.
Risk: Battery cable contact with the exhaust manifold and heat shield can increase the risk of a fire.
Fix: TMC will notify owners, and dealers will inspect the routing of the battery cable. If needed the cable will be re-routed and properly secured, free of charge. This recall began September 11, 2020. Owners may contact TMC customer service at 1-877-855-2867. TMC's number for this recall is RC000197.
Electronic stability control (esc); electrical system:wiring; service brakes, hydraulic:antilock/traction control/electronic limited slip
Problem: Thor Motor Coach (TMC) is recalling certain 2020-2021 Quantum, Chateau and Four Winds, and 2020 Vegas and Axis motorhomes built on a Ford E-series chassis. A wire harness in the rear of the vehicle may contact the vehicle frame, resulting in damage to the circuits that support the fuel pump and the anti-lock braking system (ABS).
Risk: Damage to the fuel pump circuit in the wiring harness could result in an unexpected engine stall. Damage to the ABS wiring can lead to reduction of ABS functionality and a loss of roll stability control (RSC) functionality. These scenarios increase the risk of a crash.
Fix: TMC will notify owners, and Ford dealers will inspect the wire harness for damage. If no damage is found, dealers will apply anti-abrasion tape over the area and ensure clearance to surrounding components. If damage is found, dealers will splice in new wire and apply anti-abrasion tape over the area and ensure clearance to surrounding components. All services will be performed free of charge. The recall The recall began June 25, 2020., 2020. Owners may contact TMC customer service at 1-877-855-2867. TMC's number for this recall is RC000189.
To see whether a specific car still has an open recall, enter its VIN on NHTSA's official recall lookup. You can also decode a VIN here.
Recent owner reports
Short excerpts of the latest complaints filed with NHTSA, with personal details removed. Full reports can be searched on NHTSA.gov.
The contact owns a 2021 Ford E-450. The contact received notification of NHTSA Campaign Number: 20V795000 (ENGINE) on the 2021 Thor Motor Coach; however, when the dealer was contacted to schedule an appointment for the recall repair, the contact was informed that the VIN was not under recall. The…
Driving on I-10 on December 12, 2024, the Solar Panel flew off the roof of my 2021 Thor Chateaux 27R and into the ditch. My wife following the RV in our other vehicle saw it happen. Luckily no one was hit by the panel as it could have been deadly serious. Looking at the roof later, I found two…
Other Thor Motor Coach Chateau years
← 2020 Chateau · 2022 Chateau →
| Year | Complaints | Recalls |
|---|---|---|
| 2026 Chateau | 0 | 2 |
| 2025 Chateau | 0 | 2 |
| 2024 Chateau | 1 | 1 |
| 2023 Chateau | 0 | 2 |
| 2022 Chateau | 0 | 2 |
| 2021 | 2 | 2 |
| 2020 Chateau | 0 | 7 |
| 2019 Chateau | 0 | 3 |
| 2018 Chateau | 5 | 5 |
| 2017 Chateau | 2 | 5 |
| 2016 Chateau | 1 | 4 |
| 2015 Chateau | 2 | 3 |
| 2014 Chateau | 2 | 2 |
| 2013 Chateau | 1 | 2 |
| 2012 Chateau | 0 | 3 |
| 2011 Chateau | 0 | 3 |
| 2010 Chateau | 0 | 2 |
| 2009 Chateau | 0 | 1 |
| 2008 Chateau | 0 | 1 |
| 2007 Chateau | 0 | 1 |
| 2006 Chateau | 0 | 1 |
| 2005 Chateau | 0 | 1 |
| 2004 Chateau | 0 | 1 |
| 2003 Chateau | 0 | 1 |
See all Thor Motor Coach Chateau problems by year, every Thor Motor Coach model, or the VIN decoder.
Similar Thor Motor Coach models
Embed this 2021 Thor Motor Coach Chateau badge on your site
Copy this code into your blog or forum post. It shows live complaint and recall counts and links back here.
Frequently asked questions
What are the most common problems with the 2021 Thor Motor Coach Chateau?
Owners most often report engine, unknown or other problems. The top one, engine, accounts for 1 complaint.
Was there a recall on the 2021 Thor Motor Coach Chateau?
Yes, 2 safety recalls. Enter your VIN at NHTSA.gov to check whether the repairs were done on your car.
Was the 2021 Thor Motor Coach Chateau a good year?
Complaint data can't fully answer that, because counts aren't adjusted for sales. Compared with other Chateau model years, the 2021 has too little data to compare. Always get a pre-purchase inspection and check the VIN for open recalls.