2002 Volvo Wxll Problems, Complaints & Recalls
- Compared with other Wxll years
- Not enough data 4th of 10 for complaints
- Safety recalls
- 3 recalls: check your VIN
- NHTSA crash rating
- Not rated
NHTSA has received no owner complaints about the 2002 Volvo Wxll so far. There are 3 safety recalls covering this model year.
- 0owner complaints
- 3safety recalls
- 0NHTSA investigations
- 0complaints mentioning a crash
Complaints are unverified owner reports and are not adjusted for sales volume.
2002 Volvo Wxll recalls (3)
Tap a recall to see the problem, the risk and the fix.
Power train:automatic transmission
Problem: On certain heavy-duty class 8 vehicles, the body builder wiring option was mis-wired in such a way that the auto neutral with service brake status option may allow the transmission to go into forward gear without the driver's foot pressing down on the brake pedal first.
Risk: Unintended movement of the vehicle could put persons in danger inside and outside the vehicle.
Fix: Volvo trucks will notify its customers and install an additional air operated stop light switch and the necessary wiring changes. Owner notification is expected to begin during september 2003. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact at 1-800-528-6586.
Engine and engine cooling:engine:diesel
Problem: On certain transit buses equipped with cummins westport b gas plus or c gas plus 6 cylinder engines, the electronic control module calibration may not correctly detect a throttle plate actuator failure that could result in an uncommanded open throttle condition.
Risk: If this event occurs, the vehicle operator will not have control of the engine speed which could possibly result in a vehicle crash.
Fix: Dealers will replace the electronic control module calibration free of charge. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact cummins customer assistance center at 1-800-343-7357 or volvo truck at 1-800-528-6586.
Suspension:multiple axle
Problem: On certain heavy duty class 8 trucks with volvo b-ride rear suspension, the forward and/or rear drive axle upper axle seat could break allowing the affected axle to shift out of alignment.
Risk: This condition could result in loss of axle stability, increasing the risk of a crash.
Fix: Dealers will replace the upper axle seat on both rear drive axles. Owner notification began january 14, 2003. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact volvo trucks at 1-800-528-6586.
To see whether a specific car still has an open recall, enter its VIN on NHTSA's official recall lookup. You can also decode a VIN here.
Other Volvo Wxll years
| Year | Complaints | Recalls |
|---|---|---|
| 2004 Wxll | 1 | 1 |
| 2003 Wxll | 1 | 2 |
| 2002 | 0 | 3 |
| 2001 Wxll | 0 | 3 |
| 2000 Wxll | 0 | 3 |
| 1999 Wxll | 1 | 3 |
| 1998 Wxll | 0 | 4 |
| 1997 Wxll | 0 | 4 |
| 1996 Wxll | 0 | 1 |
| 1995 Wxll | 0 | 2 |
See all Volvo Wxll problems by year, every Volvo model, or the Volvo VIN decoder.
Similar Volvo models
Embed this 2002 Volvo Wxll badge on your site
Copy this code into your blog or forum post. It shows live complaint and recall counts and links back here.
Frequently asked questions
What are the most common problems with the 2002 Volvo Wxll?
NHTSA has no owner complaints on file yet.
Was there a recall on the 2002 Volvo Wxll?
Yes, 3 safety recalls. Enter your VIN at NHTSA.gov to check whether the repairs were done on your car.
Was the 2002 Volvo Wxll a good year?
Complaint data can't fully answer that, because counts aren't adjusted for sales. Compared with other Wxll model years, the 2002 has too little data to compare. Always get a pre-purchase inspection and check the VIN for open recalls.