2008 Dodge Sprinter 2500 Problems, Complaints & Recalls
- Compared with other Sprinter 2500 years
- Far more complaints than other years 1st of 10 for complaints
- Safety recalls
- 5 recalls: check your VIN
- NHTSA crash rating
- Not rated
Owners have filed 53 complaints with NHTSA about the 2008 Dodge Sprinter 2500. That is the most of any Sprinter 2500 model year in the database (10 years). The most reported problem area is air bags (41 complaints, 77%), typically at around 15,686 miles. Complaints mention 2 fires. There are 5 safety recalls covering this model year. NHTSA has opened 1 defect investigation involving it.
- 53owner complaints
- 5safety recalls
- 1NHTSA investigations
- 0complaints mentioning a crash
Complaints are unverified owner reports and are not adjusted for sales volume.
Most common 2008 Dodge Sprinter 2500 problems
Complaints grouped by the part of the car owners reported, with the median mileage when the problem happened.
| Problem area | Complaints | Share | Median miles | Owners mention most | Typical repair cost |
|---|---|---|---|---|---|
| Air Bags | 41 | 77% | 15,686 | — | — |
| Electrical System | 3 | 6% | 35,000 | — | — |
| Engine and Engine Cooling | 3 | 6% | 22,500 | — | — |
| Electronic Stability Control (esc) | 1 | 2% | 251,847 | — | — |
| Engine | 1 | 2% | 21,000 | — | — |
| Exterior Lighting | 1 | 2% | 18,000 | — | — |
| Fuel/propulsion System | 1 | 2% | 21,000 | — | — |
| Fuel System, Diesel | 1 | 2% | 22,500 | — | — |
| Seats | 1 | 2% | 40,000 | — | — |
| Service Brakes | 1 | 2% | 251,847 | — | — |
| Steering | 1 | 2% | 71,790 | — | — |
| Structure | 1 | 2% | 20,000 | — | — |
| Suspension | 1 | 2% | 224,000 | — | — |
| Vehicle Speed Control | 1 | 2% | 251,847 | — | — |
One complaint can list several problem areas, so shares can add up to more than 100%.
Complaints by year received
2008 Dodge Sprinter 2500 recalls (5)
Tap a recall to see the problem, the risk and the fix.
Air bags:frontal:passenger side:inflator module
Problem: Daimler Vans USA, LLC (DVUSA) is recalling certain 2007-2009 Freightliner and Dodge Sprinter 2500 and 3500 vehicles. These vehicles are equipped with certain air bag inflators assembled into the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Risk: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Fix: DVUSA will notify owners, and dealers will replace the passenger side frontal air bag, free of charge. The recall began on September 29, 2017. Owners may contact DVUSA customer service at 1-877-762-8267. Note: This recall fully supersedes recall 15V-354 and partially supersedes recalls 16V-379 and 17V-025.
Air bags:frontal:driver side:inflator module
Problem: Daimler Vans USA, LLC (Daimler Vans) is recalling certain model year 2007-2009 Dodge Sprinter 2500 and 3500 vehicles manufactured July 1, 2006, to July 31, 2008, 2007-2014 Freightliner Sprinter 2500 and 3500 vehicles manufactured July 1, 2006, to July 1, 2014, and 2010-2014 Mercedes Benz Sprinter 2500 and 3500 vehicles manufactured July 1, 2010, to July 1, 2014. Upon deployment of the driver's frontal air bag, excessive internal pressure may cause the inflator to rupture.
Risk: In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could rupture with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.
Fix: Daimler Vans will notify the Mercedes-Benz and Freightliner owners and Fiat Chrysler will notify the Dodge owners. The respective dealers will replace the driver frontal air bag inflator, free of charge. The recall began March 31, 2017. Mercedes-Benz and Freightliner owners may contact Daimler Van's customer service at 1-877-762-8267. Dodge owners may contact Fiat Chrysler customer service at 1-800-853-1403.
Seat belts
Problem: Mercedes-benz is recalling certain model year 2008-2011 2500 and 3500 sprinter vehicles equipped with an optional three-seat bench in the passenger compartment. The seat benches in the second seating row may have been equipped with safety belts that do not meet the minimum requirements of federal motor vehicle safety standard 208, "occupant protection in interior impact," and motor vehicle safety standard 209, "seat belt assemblies." first, those safety belts may not lock as required. Second, the assembly loop may not perform to minimum force requirements.
Risk: In the event of a crash, the safety belts in these vehicles may not perform as required such that a seat occupant may not be properly restrained, increasing the risk of injury or death in the event of a crash.
Fix: Mercedes-benz will inspect and replace any seat belt assemblies that do not meet the requirements free of charge. The safety recall began on july 15, 2011. Owners may contact mercedes-benz at 843-695-5000.
Suspension:rear:springs
Problem: Sprinter is recalling 246 my 2008 dodge or freightliner 2500 trucks. The rear axle spring leaves were produced with an incorrect raw material. Therefore the leaves are thicker than the serial components.
Risk: The rear axle springs may fail earlier than designed increasing the risk of a crash.
Fix: Dealers will inspect and replace the rear axle springs free of charge. The recall began on november 3, 2008. Owners may contact sprinter at 1-843-695-5000.
Structure
Problem: Chrysler/sprinter is recalling 727 my 2007-2008 dodge and freightliner sprinter 2500 passenger vans equipped with 144 inch wheelbase and standard roof height. These vans fail to comply with the requirements of federal motor vehicle safety standard no. 201u, 'occupant protection in interior impact.' some vans may not have had certain head impact protection pads installed at the c-pillar.
Risk: In the event of a vehicle crash, personal injury to occupants may occur.
Fix: Dealers will inspect the vehicles and, if the head impact protection pads are missing, the appropriate pads will be installed. The recall began on april 9, 2008. Owners may contact sprinter at 1-800-853-1403.
To see whether a specific car still has an open recall, enter its VIN on NHTSA's official recall lookup. You can also decode a VIN here.
NHTSA defect investigations
- Desiccated Air Bag Inflator Rupture (EA21002) — opened Sep 17, 2021, still open.
Recent owner reports
Short excerpts of the latest complaints filed with NHTSA, with personal details removed. Full reports can be searched on NHTSA.gov.
The contact owns a 2008 Dodge Sprinter 2500. The contact stated that on several occasions while driving at undisclosed speeds, the vehicle lost motive power. The contact stated that on one occasion, while driving 60 MPH, the vehicle lost motive power and decelerated to 40 MPH, almost causing a…
The recalls are for 2016-2015 airbags component. I had called every dodge dealership within my 50miles distance and mercedes benz and they dont have the part to perform the repair or they mention they have no space for the vehicle. There never been any accidents. Its just a recall from…
I have a Mercedes Sprinter Van that has a Dodge Vin number and no one wants to provide the replacement of the Airbag in the vehicle. Mercedes says its a Dodge and the Dodge Dealership in Freehold said they can not work on it since it has a Mercedes Emblem on it.
The contact owns a 2008 Dodge Sprinter 2500. The contact stated that while self-inspecting the vehicle, he noticed that both rear axles were detached. The vehicle was taken to an independent mechanic, who informed the contact that both rear springs had a cracked eye on the rear axles. The vehicle…
I am reaching out for assistance in resolving a passenger air bag issue in my 2008 Dodge Sprinter RV (Case 84229129 for codes R49 and S14). Fiat/Chrysler(FCA) notified us of a recall associated with both the driver and passenger airbags in September, 2022. We took the vehicle to Bob Brady Chrysler…
Other Dodge Sprinter 2500 years
← 2007 Sprinter 2500 · 2009 Sprinter 2500 →
| Year | Complaints | Recalls |
|---|---|---|
| 2013 Sprinter 2500 | 2 | 0 |
| 2009 Sprinter 2500 | 3 | 4 |
| 2008 | 53 | 5 |
| 2007 Sprinter 2500 | 24 | 5 |
| 2006 Sprinter 2500 | 34 | 5 |
| 2005 Sprinter 2500 | 21 | 3 |
| 2004 Sprinter 2500 | 12 | 3 |
| 2003 Sprinter 2500 | 5 | 5 |
| 2002 Sprinter 2500 | 0 | 4 |
| 2001 Sprinter 2500 | 1 | 2 |
See all Dodge Sprinter 2500 problems by year, every Dodge model, or the Dodge VIN decoder.
Similar Dodge models
Embed this 2008 Dodge Sprinter 2500 badge on your site
Copy this code into your blog or forum post. It shows live complaint and recall counts and links back here.
Frequently asked questions
What are the most common problems with the 2008 Dodge Sprinter 2500?
Owners most often report air bags, electrical system, engine and engine cooling problems. The top one, air bags, accounts for 41 complaints.
Was there a recall on the 2008 Dodge Sprinter 2500?
Yes, 5 safety recalls. Enter your VIN at NHTSA.gov to check whether the repairs were done on your car.
Was the 2008 Dodge Sprinter 2500 a good year?
Complaint data can't fully answer that, because counts aren't adjusted for sales. Compared with other Sprinter 2500 model years, the 2008 has far more complaints than most years. Always get a pre-purchase inspection and check the VIN for open recalls.