2002 Volvo VNM Problems, Complaints & Recalls

Problem: Volvo trucks is recalling certain model year 2001-2006 vnl and vnm trucks manufactured with a trw sealed drag links. Certain factors can exist, which if left untreated may result in a ball socket separation.

Risk: Ball socket separation at the drag link results in complete loss of steering, and therefore can result in a vehicle crash.

Fix: Dealers will inspect and repair the ball socket or the drag link as required if necessary. As parts are limited, volvo trucks mailed an interim owner letter on september 2, 2010. The safety recall began on february 14, 2011. Owners may contact volvo trucks at 1-800-528-6586.

Problem: Volvo trucks is recalling 127,764 my 2001-2008 vhd, vnl, vnm, and my 2005-2008 vt trucks. A seal may fail allowing water and contaminants to seep into the windshield wiper motor.

Risk: If this happens a short circuit may occur, which over time could possibly lead to a vehicle fire.

Fix: Volvo will replace the wiper motor free of charge. Since this recall involves a large number of vehicles, volvo will release the recall in stages as parts are received. Priority will be given to the vehicles located in the regions/states that have a corrosive environment. The recall began on september 30, 2009. Owners may contact volvo trucks at 1-800-528-6586.

Problem: On certain heavy-duty class trucks, salt and other highway snow and ice removal chemicals are getting under the protective caps of the chassis mounted emergency start studs and corroding them. This condition deteriorates the studs and the connections.

Risk: Over time the studs may loosen sufficiently to cause an electrical short.

Fix: Dealers will install new chassis mounted emergency start studs and associated battery cables. Owner notification is expected to begin during november 2003. Owners should contact volvo at 1-800-528-6586.

Problem: On certain heavy duty trucks equipped with jost international jsk 37u series fifth wheels, a fatigue crack can develop in the bracket pin weld under certain loading conditions.

Risk: If left undetected or corrected it could lead to the separation of the fifth wheel top plate from its mounting structure, possibly resulting in a crash.

Fix: Dealers will replace the bracket pins and repair instructions free of charge. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact jost international at 616-846-7700 or by email to [email protected] or volvo truck at 800-528-6586.

Problem: On certain trucks equipped with truck hub units manufactured by skf exclusively for use on arvinmeritor's ff98x series non-drive steer axles, the hub unit bearings can wear prematurely.

Risk: Seizure of the bearings can cause wheel separation or wheel end fire.

Fix: Dealers will replace all front axle hubs. An interim notice to owners was mailed on june 25, 2003. Final owner notification began on october 6, 2003. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact volvo at 1-800-528-6586.

Problem: Certain heavy duty class 8 trucks fail to comply with the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." the two tail lamps, back-up lamp,and license tag lamp were mounted on insufficiently rigid mounts.

Risk: It may not allow the driver of a rearward approaching vehicle to have full view of the lamps.

Fix: Dealers will attach the two tail lamps, back-up lamp, and the license tap lamp on stiffer brackets. Owner notification began october 31, 2002. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact volvo trucks at 1-800-528-6586.