2005 Bigdog Mastiff Problems, Complaints & Recalls
- Compared with other Mastiff years
- Not enough data 3rd of 6 for complaints
- Safety recalls
- 8 recalls: check your VIN
- NHTSA crash rating
- Not rated
Owners have filed 2 complaints with NHTSA about the 2005 Bigdog Mastiff. That ranks 3rd out of 6 Mastiff model years for complaints. The most reported problem area is electrical system (1 complaints, 50%). There are 8 safety recalls covering this model year.
- 2owner complaints
- 8safety recalls
- 0NHTSA investigations
- 0complaints mentioning a crash
Complaints are unverified owner reports and are not adjusted for sales volume.
Most common 2005 Bigdog Mastiff problems
Complaints grouped by the part of the car owners reported, with the median mileage when the problem happened.
| Problem area | Complaints | Share | Median miles | Owners mention most | Typical repair cost |
|---|---|---|---|---|---|
| Electrical System | 1 | 50% | — | — | — |
| Engine and Engine Cooling | 1 | 50% | — | — | — |
| Power Train | 1 | 50% | 6,800 | — | — |
One complaint can list several problem areas, so shares can add up to more than 100%.
Complaints by year received
2005 Bigdog Mastiff recalls (8)
Tap a recall to see the problem, the risk and the fix.
Structure:body
Problem: On certain motorcycles, the rear fender strut attaching bolts can fail allowing the rear fender to detach from the motorcycle.
Risk: This could occur without prior warning and could result in an injury or a crash.
Fix: Dealers will remove existing strut bolts and replace with higher tensile strength attaching bolts and updated washers. Higher torque values will be observed when installing the replacement fasteners. The recall began on january 21, 2008. Owners may contact big dog at 316-267-9121.
Electrical system:alternator/generator/regulator
Problem: On certain motorcycles, a warped bus bar within the voltage regulator can cause a short circuit.
Risk: This could possibly result in a fire.
Fix: Dealers will replace the existing circuit breaker located between the voltage regulator positive battery lead (b+ lead) and the positive battery terminal with an alternative circuit protection device that will prevent a thermal event if there is a short to ground. The recall began on october 1, 2007. Owners may contact big dog at 1-316-219-9129 or email to [email protected].
Structure
Problem: On certain motorcycles, the long pivot bolt may bend or break during normal operation of the motorcycle.
Risk: This could potentially cause the rear fender to abrade against the rear tire while the motorcycle is being driven. This condition could occur without any prior warning and could result in a crash.
Fix: Dealers will replace the long pivot bolt and, if necessary, straighten the rear frame side panel. The short left side pivot bolt and pivot shaft may also be replaced free of charge. The recall began on november 1, 2006. Owners may contact big dog at 316-267-9121.
Electrical system
Problem: On certain motorcycles, the electronic harness control (ehc) module can fail resulting in a total shut down of the vehicle's electronic power.
Risk: This condition could occur without any prior warning and could result in a crash.
Fix: Dealers will replace the ehc modules free of charge. The recall began on september 19, 2006. Owners may contact big dog at 316-267-9121.
Electrical system:ignition:module
Problem: On certain motorcycles, the ignition modules are oriented within the battery tray in a way that makes the ignition module susceptible to vibration.
Risk: This susceptibility to vibration may contribute to a stalling condition that could occur without any prior warning and result in a crash.
Fix: Dealers will install a new ignition module mounting system free of charge. The recall began on august 25, 2006. Owners may contact big dog at 316-267-9121.
Structure:motorcycle:kickstand/center stand
Problem: On certain motorcycles, the kickstand spring may stretch and detach from the mounting bracket or the kickstand.
Risk: This will allow the kickstand to deploy into the extended position and cause a crash.
Fix: Dealers will install a new kickstand spring free of charge. The recall began on february 17, 2006. Owners may contact big dog at 316-267-9121.
Wheels:lugs/nuts/bolts/studs
Problem: On certain motorcycles, the rear wheel hub bolts could loosen and back out allowing the hub and brake rotor to detach from the wheel with an associated loss of stopping power.
Risk: This condition could occur without any prior warning and could result in a crash.
Fix: Dealers will remove, clean and reattach the rear hub bolts free of charge. The recall began on october 14, 2005. Owners may contact big dog at 1-312-267-9121.
Power train
Problem: On certain motorcycles, the primary drive sprocket nut may back off the engine main shaft.
Risk: This could cause the primary drive to lock up and cause a crash. This condition could occur without any prior warning.
Fix: Dealers will inspect and replace the drive sprocket nut free of charge. The recall began on may 13, 2005. Owners may contact big dog at 316-267-9121.
To see whether a specific car still has an open recall, enter its VIN on NHTSA's official recall lookup. You can also decode a VIN here.
Recent owner reports
Short excerpts of the latest complaints filed with NHTSA, with personal details removed. Full reports can be searched on NHTSA.gov.
2005 big dog mastiff motorcycle. Is known for having a bad ehc units. Ehc is the brain box of the motorcycle when this fails it shuts down the motorcycle lights and everything. Had this happen on mine numerous times. Got different ehc unit haven't had the problem since. Ok next problem with bike is…
Several events have been listed and submitted to the dealer. The dealer has attempted many times to fix the problem, with no success. The dealer sent the motorcycle to the headquarters in another city, still unable to keep the bike from pouring oil out at high speeds. This is getting oil on the…
Other Bigdog Mastiff years
← 2004 Mastiff · 2006 Mastiff →
| Year | Complaints | Recalls |
|---|---|---|
| 2008 Mastiff | 1 | 2 |
| 2007 Mastiff | 3 | 1 |
| 2006 Mastiff | 1 | 6 |
| 2005 | 2 | 8 |
| 2004 Mastiff | 6 | 5 |
| 2003 Mastiff | 0 | 1 |
See all Bigdog Mastiff problems by year, every Bigdog model, or the VIN decoder.
Similar Bigdog models
Embed this 2005 Bigdog Mastiff badge on your site
Copy this code into your blog or forum post. It shows live complaint and recall counts and links back here.
Frequently asked questions
What are the most common problems with the 2005 Bigdog Mastiff?
Owners most often report electrical system, engine and engine cooling, power train problems. The top one, electrical system, accounts for 1 complaint.
Was there a recall on the 2005 Bigdog Mastiff?
Yes, 8 safety recalls. Enter your VIN at NHTSA.gov to check whether the repairs were done on your car.
Was the 2005 Bigdog Mastiff a good year?
Complaint data can't fully answer that, because counts aren't adjusted for sales. Compared with other Mastiff model years, the 2005 has too little data to compare. Always get a pre-purchase inspection and check the VIN for open recalls.