2006 Bigdog Mastiff Problems, Complaints & Recalls
- Compared with other Mastiff years
- Not enough data 4th of 6 for complaints
- Safety recalls
- 6 recalls: check your VIN
- NHTSA crash rating
- Not rated
Owners have filed 1 complaint with NHTSA about the 2006 Bigdog Mastiff. That ranks 4th out of 6 Mastiff model years for complaints. The most reported problem area is electrical system (1 complaints, 100%), typically at around 12,000 miles. Complaints mention 1 fire. There are 6 safety recalls covering this model year.
- 1owner complaints
- 6safety recalls
- 0NHTSA investigations
- 0complaints mentioning a crash
Complaints are unverified owner reports and are not adjusted for sales volume.
Most common 2006 Bigdog Mastiff problems
Complaints grouped by the part of the car owners reported, with the median mileage when the problem happened.
| Problem area | Complaints | Share | Median miles | Owners mention most | Typical repair cost |
|---|---|---|---|---|---|
| Electrical System | 1 | 100% | 12,000 | — | — |
One complaint can list several problem areas, so shares can add up to more than 100%.
2006 Bigdog Mastiff recalls (6)
Tap a recall to see the problem, the risk and the fix.
Structure:body
Problem: On certain motorcycles, the rear fender strut attaching bolts can fail allowing the rear fender to detach from the motorcycle.
Risk: This could occur without prior warning and could result in an injury or a crash.
Fix: Dealers will remove existing strut bolts and replace with higher tensile strength attaching bolts and updated washers. Higher torque values will be observed when installing the replacement fasteners. The recall began on january 21, 2008. Owners may contact big dog at 316-267-9121.
Electrical system:alternator/generator/regulator
Problem: On certain motorcycles, a warped bus bar within the voltage regulator can cause a short circuit.
Risk: This could possibly result in a fire.
Fix: Dealers will replace the existing circuit breaker located between the voltage regulator positive battery lead (b+ lead) and the positive battery terminal with an alternative circuit protection device that will prevent a thermal event if there is a short to ground. The recall began on october 1, 2007. Owners may contact big dog at 1-316-219-9129 or email to [email protected].
Structure
Problem: On certain motorcycles, the long pivot bolt may bend or break during normal operation of the motorcycle.
Risk: This could potentially cause the rear fender to abrade against the rear tire while the motorcycle is being driven. This condition could occur without any prior warning and could result in a crash.
Fix: Dealers will replace the long pivot bolt and, if necessary, straighten the rear frame side panel. The short left side pivot bolt and pivot shaft may also be replaced free of charge. The recall began on november 1, 2006. Owners may contact big dog at 316-267-9121.
Electrical system
Problem: On certain motorcycles, the electronic harness control (ehc) module can fail resulting in a total shut down of the vehicle's electronic power.
Risk: This condition could occur without any prior warning and could result in a crash.
Fix: Dealers will replace the ehc modules free of charge. The recall began on september 19, 2006. Owners may contact big dog at 316-267-9121.
Electrical system:ignition:module
Problem: On certain motorcycles, the ignition modules are oriented within the battery tray in a way that makes the ignition module susceptible to vibration.
Risk: This susceptibility to vibration may contribute to a stalling condition that could occur without any prior warning and result in a crash.
Fix: Dealers will install a new ignition module mounting system free of charge. The recall began on august 25, 2006. Owners may contact big dog at 316-267-9121.
Structure:motorcycle:kickstand/center stand
Problem: On certain motorcycles, the kickstand spring may stretch and detach from the mounting bracket or the kickstand.
Risk: This will allow the kickstand to deploy into the extended position and cause a crash.
Fix: Dealers will install a new kickstand spring free of charge. The recall began on february 17, 2006. Owners may contact big dog at 316-267-9121.
To see whether a specific car still has an open recall, enter its VIN on NHTSA's official recall lookup. You can also decode a VIN here.
Recent owner reports
Short excerpts of the latest complaints filed with NHTSA, with personal details removed. Full reports can be searched on NHTSA.gov.
Tl*the contact owns a 2006 big dog mastiff motorcycle. The contact was driving approximately 35 mph when he smelled a burning odor. He noticed that the voltage regulator was on fire. He drove onto the emergency lane, turned the vehicle off, cut the wire on the regulator, and threw dirt on it. He…
Other Bigdog Mastiff years
← 2005 Mastiff · 2007 Mastiff →
| Year | Complaints | Recalls |
|---|---|---|
| 2008 Mastiff | 1 | 2 |
| 2007 Mastiff | 3 | 1 |
| 2006 | 1 | 6 |
| 2005 Mastiff | 2 | 8 |
| 2004 Mastiff | 6 | 5 |
| 2003 Mastiff | 0 | 1 |
See all Bigdog Mastiff problems by year, every Bigdog model, or the VIN decoder.
Similar Bigdog models
Embed this 2006 Bigdog Mastiff badge on your site
Copy this code into your blog or forum post. It shows live complaint and recall counts and links back here.
Frequently asked questions
What are the most common problems with the 2006 Bigdog Mastiff?
Owners most often report electrical system problems. The top one, electrical system, accounts for 1 complaint.
Was there a recall on the 2006 Bigdog Mastiff?
Yes, 6 safety recalls. Enter your VIN at NHTSA.gov to check whether the repairs were done on your car.
Was the 2006 Bigdog Mastiff a good year?
Complaint data can't fully answer that, because counts aren't adjusted for sales. Compared with other Mastiff model years, the 2006 has too little data to compare. Always get a pre-purchase inspection and check the VIN for open recalls.