2025 Thomas Built Buses SAF-T-Liner HDX Problems, Complaints & Recalls
- Compared with other SAF-T-Liner HDX years
- Not enough data 5th of 25 for complaints
- Safety recalls
- 3 recalls: check your VIN
- NHTSA crash rating
- Not rated
NHTSA has received no owner complaints about the 2025 Thomas Built Buses SAF-T-Liner HDX so far. There are 3 safety recalls covering this model year.
- 0owner complaints
- 3safety recalls
- 0NHTSA investigations
- 0complaints mentioning a crash
Complaints are unverified owner reports and are not adjusted for sales volume.
2025 Thomas Built Buses SAF-T-Liner HDX recalls (3)
Tap a recall to see the problem, the risk and the fix.
Engine and engine cooling:cooling system:hoses/lines/piping/fittings
Problem: Daimler Trucks North America, LLC (DTNA) is recalling certain Thomas Built Buses 2023-2026 Saf-T-Liner EFX and Saf-T-Liner HDX school buses. The heater hose clamps may not have been tightened properly, causing the hose to disconnect and leak heating coolant inside the passenger compartment.
Risk: Contact with hot heating coolant may burn occupants, increasing the risk of injury.
Fix: Dealers will inspect and replace the heater hose clamps, as necessary, free of charge. Owner notification letters were mailed April 10, 2026. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is F1030.
Engine and engine cooling:cooling system:hoses/lines/piping/fittings
Problem: Daimler Trucks North America, LLC (DTNA) is recalling certain Thomas Built Buses 2023-2025 Saf-T-Liner EFX and 2023-2026 Saf-T-Liner HDX vehicles. The heater hose clamps may not have been tightened properly, causing the hose to disconnect and leak heating coolant inside the passenger compartment.
Risk: Contact with hot heating coolant may burn occupants, increasing the risk of injury.
Fix: Dealers will inspect and replace the heater hose clamps, as necessary, free of charge. Owner notification letters were mailed April 10, 2026. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is F1030.
Steering:critical fasteners; steering:linkages:tie rod assembly
Problem: Daimler Trucks North America, LLC (DTNA) is recalling certain Thomas Built Buses 2025-2026 Saf-T-Liner HDX, Saf-T-Liner C2, 2026 Saf-T-Liner EFX, and Saf-T-Liner C2 Jouley school buses. The tie rod castle nut and cotter pin may not be installed properly, which can result in a loss of vehicle steering control.
Risk: A loss of vehicle steering control increases the risk of a crash.
Fix: Dealers will inspect and replace the tie rod assembly, as necessary, free of charge. Owner notification letters were mailed November 10, 2025. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is D25R2.
To see whether a specific car still has an open recall, enter its VIN on NHTSA's official recall lookup. You can also decode a VIN here.
Other Thomas Built Buses SAF-T-Liner HDX years
← 2024 SAF-T-Liner HDX · 2026 SAF-T-Liner HDX →
See all Thomas Built Buses SAF-T-Liner HDX problems by year, every Thomas Built Buses model, or the VIN decoder.
Embed this 2025 Thomas Built Buses SAF-T-Liner HDX badge on your site
Copy this code into your blog or forum post. It shows live complaint and recall counts and links back here.
Frequently asked questions
What are the most common problems with the 2025 Thomas Built Buses SAF-T-Liner HDX?
NHTSA has no owner complaints on file yet.
Was there a recall on the 2025 Thomas Built Buses SAF-T-Liner HDX?
Yes, 3 safety recalls. Enter your VIN at NHTSA.gov to check whether the repairs were done on your car.
Was the 2025 Thomas Built Buses SAF-T-Liner HDX a good year?
Complaint data can't fully answer that, because counts aren't adjusted for sales. Compared with other SAF-T-Liner HDX model years, the 2025 has too little data to compare. Always get a pre-purchase inspection and check the VIN for open recalls.