1996 Kenworth C500 Problems, Complaints & Recalls
- Compared with other C500 years
- Not enough data 6th of 30 for complaints
- Safety recalls
- 4 recalls: check your VIN
- NHTSA crash rating
- Not rated
NHTSA has received no owner complaints about the 1996 Kenworth C500 so far. There are 4 safety recalls covering this model year.
- 0owner complaints
- 4safety recalls
- 0NHTSA investigations
- 0complaints mentioning a crash
Complaints are unverified owner reports and are not adjusted for sales volume.
1996 Kenworth C500 recalls (4)
Tap a recall to see the problem, the risk and the fix.
Service brakes, air
Problem: Certain trucks equipped with meritor p 18x7 brakes with 36" brake chambers fail to comply with the requirements of federal motor vehicle safety standard (fmvss) no. 121, "air brake systems." these trucks were manufactured with a combined air reservoir volume less than 12 times the combined volume of all service brake chambers.
Risk: This does not meet the requirements of the standard.
Fix: Dealers will add an additional tank or change one of the existing air tanks to a larger size. Owner notification began on may 5, 2003. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact kenworth at 1-425-828-5440.
Suspension:front:control arm:lower arm
Problem: Vehicle description: vehicles equipped with 54" rear axle spacing configuration of the airglide 200 suspension with the service application identified as logger, dump truck, or tanker. The rear suspension is regularly subjected to extreme articulation, resulting in flexing of the joint.
Risk: Failure of the lower sway arm attaching bolts could result in loss of vehicle control.
Fix: Dealers will replace the lower sway arm brackets. Owner notification began march 27, 2001. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact kenworth at 1-425-828-5000.
Electrical system:wiring:front underhood
Problem: Vehicle description: heavy duty trucks equipped with caterpillar 3406e engines. The routing of the electrical and fuel lines can cause chaffing of the wiring harness on the fuel line.
Risk: This chaffing can cause fuel leakage and a potential for a fire in the engine compartment.
Fix: Dealers will inspect, adjust, and repair, if necessary, the fuel line and electrical harness.
Exterior lighting:turn signal:switch
Problem: The wires that correspond to the vehicle's rear turn signals were reversed when installed in the electrical connector.
Risk: This condition will cause the rear turn signals to flash opposite from the direction intended by the driver increasing the risk of a vehicle accident.
Fix: Dealers will inspect the turn signal switch and, if necessary, replace the turn signal switch.
To see whether a specific car still has an open recall, enter its VIN on NHTSA's official recall lookup. You can also decode a VIN here.
Other Kenworth C500 years
| Year | Complaints | Recalls |
|---|---|---|
| 2025 C500 | 0 | 1 |
| 2023 C500 | 0 | 1 |
| 2022 C500 | 0 | 1 |
| 2021 C500 | 0 | 1 |
| 2020 C500 | 0 | 1 |
| 2019 C500 | 0 | 4 |
| 2018 C500 | 0 | 5 |
| 2017 C500 | 0 | 4 |
| 2016 C500 | 0 | 3 |
| 2015 C500 | 0 | 3 |
| 2014 C500 | 0 | 4 |
| 2013 C500 | 0 | 2 |
| 2012 C500 | 1 | 3 |
| 2011 C500 | 0 | 6 |
| 2010 C500 | 1 | 4 |
| 2009 C500 | 0 | 5 |
| 2008 C500 | 0 | 9 |
| 2007 C500 | 1 | 6 |
| 2006 C500 | 1 | 5 |
| 2005 C500 | 0 | 5 |
| 2004 C500 | 0 | 4 |
| 2003 C500 | 0 | 3 |
| 2002 C500 | 0 | 2 |
| 2001 C500 | 0 | 4 |
| 2000 C500 | 0 | 7 |
| 1999 C500 | 1 | 7 |
| 1998 C500 | 0 | 3 |
| 1997 C500 | 0 | 3 |
| 1996 | 0 | 4 |
| 1995 C500 | 0 | 1 |
See all Kenworth C500 problems by year, every Kenworth model, or the VIN decoder.
Similar Kenworth models
Embed this 1996 Kenworth C500 badge on your site
Copy this code into your blog or forum post. It shows live complaint and recall counts and links back here.
Frequently asked questions
What are the most common problems with the 1996 Kenworth C500?
NHTSA has no owner complaints on file yet.
Was there a recall on the 1996 Kenworth C500?
Yes, 4 safety recalls. Enter your VIN at NHTSA.gov to check whether the repairs were done on your car.
Was the 1996 Kenworth C500 a good year?
Complaint data can't fully answer that, because counts aren't adjusted for sales. Compared with other C500 model years, the 1996 has too little data to compare. Always get a pre-purchase inspection and check the VIN for open recalls.