2007 Chevrolet Suburban Problems, Complaints & Recalls
- Compared with other Suburban years
- More complaints than other years 8th of 30 for complaints
- Safety recalls
- 4 recalls: check your VIN
- NHTSA crash rating
- Not rated
Owners have filed 292 complaints with NHTSA about the 2007 Chevrolet Suburban. That ranks 8th out of 30 Suburban model years for complaints. The most reported problem area is air bags (146 complaints, 50%), typically at around 121,250 miles. Complaints mention 4 crashes, 6 fires, 44 injuries. There are 4 safety recalls covering this model year. NHTSA has opened 1 defect investigation involving it.
- 292owner complaints
- 4safety recalls
- 1NHTSA investigations
- 4complaints mentioning a crash
Complaints are unverified owner reports and are not adjusted for sales volume.
Most common 2007 Chevrolet Suburban problems
Complaints grouped by the part of the car owners reported, with the median mileage when the problem happened.
| Problem area | Complaints | Share | Median miles | Owners mention most | Typical repair cost |
|---|---|---|---|---|---|
| Air Bags problems | 146 | 50% | 121,250 | “takata air bags” (30%) | — |
| Structure | 42 | 14% | 70,000 | — | — |
| Unknown or Other | 38 | 13% | 97,500 | — | — |
| Engine | 27 | 9% | 156,000 | — | — |
| Electrical System | 25 | 9% | 71,755 | — | — |
| Latches/locks/linkages | 11 | 4% | 55,434 | — | — |
| Fuel/propulsion System | 9 | 3% | 78,268 | — | — |
| Power Train | 9 | 3% | 79,000 | — | — |
| Seat Belts | 9 | 3% | 135,000 | — | — |
| Electronic Stability Control (esc) | 8 | 3% | 152,000 | — | — |
| Engine and Engine Cooling | 6 | 2% | 55,250 | — | — |
| Steering | 5 | 2% | 185,000 | — | — |
| Equipment | 4 | 1% | 73,510 | — | — |
| Service Brakes | 4 | 1% | 93,600 | — | — |
| Suspension | 3 | 1% | 32,000 | — | — |
| Fuel System, Gasoline | 2 | 1% | 75,000 | — | — |
| Service Brakes, Hydraulic | 2 | 1% | 50,000 | — | — |
| Visibility | 2 | 1% | 73,510 | — | — |
| Back Over Prevention | 1 | 0% | — | — | — |
| Exterior Lighting | 1 | 0% | — | — | — |
| Forward Collision Avoidance | 1 | 0% | — | — | — |
| Tires | 1 | 0% | 66,945 | — | — |
| Traction Control System | 1 | 0% | 170,000 | — | — |
| Vehicle Speed Control | 1 | 0% | 78,268 | — | — |
| Visibility/wiper | 1 | 0% | 80,000 | — | — |
One complaint can list several problem areas, so shares can add up to more than 100%.
Complaints by year received
2007 Chevrolet Suburban recalls (4)
Tap a recall to see the problem, the risk and the fix.
Air bags:frontal:passenger side:inflator module
Problem: General Motors, LLC (GM) is recalling certain 2007-2011 Cadillac Escalade, Escalade ESV, Escalade EXT, Chevrolet Avalanche, Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, Yukon XL, and 2009-2011 Chevrolet Silverado 2500, Silverado 3500, GMC Sierra 2500 and Sierra 3500 vehicles originally sold, or ever registered, in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." Additionally, GM is recalling certain 2007-2008 Cadillac Escalade, Escalade ESV, Escalade EXT, Chevrolet Avalanche, Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, Yukon XL vehicles originally sold, or ever registered, in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." These vehicles are equipped with non-desiccated passenger frontal inflators containing phase-stabilized ammonium nitrate (PSAN) propellant. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Risk: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Fix: GM will notify owners, and dealers will replace the front passenger air bag inflator with an alternate one, free of charge. Interim letters notifying owners of the safety risk were mailed on February 22, 2021. Second notification letters will be mailed once the remedy is available. Owner notification letters were mailed on March 1, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020; Cadillac customer service at 1-800-458-8006; and GMC customer service at 1-800-462-8782. GM's number for this recall is N212328760.
Air bags:frontal:passenger side:inflator module
Problem: General Motors, LLC (GM) is recalling certain 2009 Cadillac Escalade, Escalade ESV, Escalade EXT, Chevrolet Avalanche, Silverado 1500, Silverado 2500, Silverado 3500, Suburban, Tahoe, GMC Sierra 1500, Sierra 2500, Sierra 3500, Yukon, and Yukon XL vehicles originally sold, or ever registered, in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." Additionally, GM is recalling certain 2007-2008 Cadillac Escalade, Escalade ESV, and Escalade EXT, Chevrolet Avalanche, Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles originally sold, or ever registered, in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming or "Zone C." These vehicles are equipped with non-desiccated passenger frontal inflators containing phase-stabilized ammonium nitrate (PSAN) propellant. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Risk: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Fix: GM will notify owners, and dealers will replace the front passenger air bag inflator with an alternate one, free of charge. Interim letters notifying owners of the safety risk were mailed on February 23, 2021. Second notification letters will be mailed once the remedy is available. Owner notification letters were mailed on September 20, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020, Cadillac customer service at 1-800-458-8006, and GMC customer service at 1-800-462-8782. GM's number for this recall is N212328780.
Electrical system
Problem: Gm is recalling certain model year 2006-2009 buick, lucerne; cadillac dts; hummer h2; model year 2008-2009 buick enclave; cadillac cts; model year 2007-2009 cadillac escalade, escalade esv, escalade ext; chevrolet avalanche, silverado, suburban, tahoe; gmc acadia, sierra, yukon, yukon xl; saturn outlook; and model year 2009 chevrolet traverse vehicles equipped with a heated washer fluid system (hwfs). A recall was implemented in 2008 to add a fuse to the control circuit harness to address the potential consequences of a printed circuit board (pcb) electrical short. However, there have been new reports of thermal incidents on hwfs modules after this improvement was installed. These incidents resulted from a new failure mode attributed to the device's thermal protection feature. The significance varies from minor distortion to considerable melting of the plastic around the hwfs fluid chamber.
Risk: It is possible for the heated washer module to ignite and a fire may occur.
Fix: Dealers will permanently disable and remove the heated washer fluid module. An updated page for the owner manual will be provided and inserted in the owner manual to document that the feature has been permanently disabled and removed from the vehicle. The safety recall began on june 11, 2010. Owners may contact buick at 1-866-608-8080, cadillac at 1-866-982-2339, chevrolet at 1-800-630-2438, saturn at 1-800-972-8876, gmc at 1-866-996-9463 and hummer at 1-800-732-5493 or at the owner center at www.gmownercenter.com.
Electrical system
Problem: Gm is recalling 857,735 my 2006-2008 buick lucerne; cadillac dts; hummer h2; my 2007-2008 cadillac escalade, escalade esv, escalade ext; chevrolet avalanche, silverado, suburban, tahoe; gmc acadia, sierra, yukon, yukon xl, saturn outlook; and my 2008 buick enclave vehicles equipped with a heated wiper washer fluid system. A short circuit on the printed circuit board for the washer fluid heater may overheat the control-circuit ground wire.
Risk: This may cause other electrical features to malfunction, create an odor, or cause smoke increasing the risk of a fire.
Fix: Dealers will install a wire harness with an in-line fuse free of charge. The recall began on september 12, 2008. Owners may contact buick at 1-866-608-8080; cadillac at 1-800-982-2339 or http://www.cadillac.com; chevrolet at 1-800-630-2438; saturn at 1-800-972-8876 or http://www.saturn.com, gmc at 1-866-996-9436; or hummer at 1-800-732-5493; or through their website at <a href=http://www.gmownercenter.com>http://www.gmownercenter.com</a> .
To see whether a specific car still has an open recall, enter its VIN on NHTSA's official recall lookup. You can also decode a VIN here.
NHTSA defect investigations
- Desiccated Air Bag Inflator Rupture (EA21002) — opened Sep 17, 2021, still open.
Recent owner reports
Short excerpts of the latest complaints filed with NHTSA, with personal details removed. Full reports can be searched on NHTSA.gov.
The lifter rod associated with the DoD/AFM system failed, causing catastrophic failure in the engine. This isn't an age issue, this isn't a part that wore out and failed. This car would still be running and driving if that system was never installed. The lifters for these systems are known…
Extensive embrittlement, cracking, and partial collapse of the plastic dash into the space underneath the dash. This cracking extends to to the boundry for the passenger side airbag cover potentially creating a dangerous situation(flying debris) during airbag deployment.
My Suburban locked itself with the keys inside of it. It is available for inspection. I had a two-month baby in the car on an 80-degree day trapped for over 10 minutes. At that young age they have no temperature regulation. I took the vehicle into a local mechanic, and it was confirmed. It has not…
There is an electrical problem with driver side door harness which causes my car not to start causing me to have to keep replacing the fuel pump from malfunction of ground wires leading to the fuel pump and ECU from what I am told
As the current investigation is going for the General Motors engines 2014-2025 5.3L and 6.2L for AFM/DFM. The same is happening with 2007 - 2014 5.3L engines with DOD. I had a 2014 Chevy Suburban with the 5.3L I had to rebuild the passenger side due to a DOD lifter failing. My current, 2007…
Other Chevrolet Suburban years
← 2006 Suburban · 2008 Suburban →
| Year | Complaints | Recalls |
|---|---|---|
| 2024 Suburban | 44 | 1 |
| 2023 Suburban | 130 | 3 |
| 2022 Suburban | 124 | 4 |
| 2021 Suburban | 200 | 12 |
| 2020 Suburban | 44 | 4 |
| 2019 Suburban | 78 | 3 |
| 2018 Suburban | 84 | 4 |
| 2017 Suburban | 141 | 5 |
| 2016 Suburban | 220 | 6 |
| 2015 Suburban | 430 | 11 |
| 2014 Suburban | 59 | 3 |
| 2013 Suburban | 118 | 4 |
| 2012 Suburban | 101 | 4 |
| 2011 Suburban | 148 | 3 |
| 2010 Suburban | 117 | 3 |
| 2009 Suburban | 106 | 5 |
| 2008 Suburban | 213 | 4 |
| 2007 | 292 | 4 |
| 2006 Suburban | 23 | 1 |
| 2005 Suburban | 129 | 6 |
| 2004 Suburban | 204 | 4 |
| 2003 Suburban | 301 | 5 |
| 2002 Suburban | 286 | 2 |
| 2001 Suburban | 440 | 6 |
| 2000 Suburban | 282 | 8 |
| 1999 Suburban | 634 | 1 |
| 1998 Suburban | 201 | 2 |
| 1997 Suburban | 414 | 2 |
| 1996 Suburban | 360 | 3 |
| 1995 Suburban | 457 | 6 |
See all Chevrolet Suburban problems by year, every Chevrolet model, or the Chevrolet VIN decoder.
Similar Chevrolet models
Embed this 2007 Chevrolet Suburban badge on your site
Copy this code into your blog or forum post. It shows live complaint and recall counts and links back here.
Frequently asked questions
What are the most common problems with the 2007 Chevrolet Suburban?
Owners most often report air bags, structure, unknown or other problems. The top one, air bags, accounts for 146 complaints.
Was there a recall on the 2007 Chevrolet Suburban?
Yes, 4 safety recalls. Enter your VIN at NHTSA.gov to check whether the repairs were done on your car.
Was the 2007 Chevrolet Suburban a good year?
Complaint data can't fully answer that, because counts aren't adjusted for sales. Compared with other Suburban model years, the 2007 has more complaints than most years. Always get a pre-purchase inspection and check the VIN for open recalls.